Product ID:MT STARTER, RP609Z
MSDS Date:03/05/1992
FSC:6850
NIIN:00N061664
MSDS Number: BYBCC

MINOLTA CORP

101 WILLIAMS DRIVE
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

CARRIER, CONTAINING INGREDIENTS 2-5

Fraction By Weight: >90%

OSHA PEL N/K

ACGIH TLV: N/K

FERRITE

CAS: 1317-54-0

RTECS: LK0495000

OSHA PEL N/K

ACGIH TLV: N/K

POLYESTER RESIN

CAS: 109909-27-5

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

AMORPHOUS SILICA

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

TONER, CONTAINING INGREDIENTS 7-9

Fraction By Weight: <10%

OSHA PEL N/K

ACGIH TLV: N/K

STYRENE ACRYLATE COPOLYMER (2 KINDS)

CAS: 25153-46-2

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

AMORPHOUS SILICA

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:LD50 (ORAL RAT): > 5.0 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: TONER PRESENTS LOW HAZ FOR
USUAL OCCUP SETTINGS. BASED ON AVAILABLE DATA, HUMAN EXPOS TO TONER
HAS BEEN SHOWN TO CAUSE MIN RESP TRACT IRRITATION AS MAY OCCUR WITH
LARGE AMOUNTS OF ANY NON-TOXIC DUSTS. THE RESULTS OF ONE ANIMAL
STUDYWHERE RATS INHALED TONER THAT WAS TEN TIMES MORE RESPIRABLE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: THAN COMMERCIALLY AVAILABLE TONER
WERE OBSERVED TO HAVE NO LUNG CHANGES AT LOW EXPOS (THE MOST
RELEVANT LEVEL TO POTENTIAL HUMAN EXPOS). AT HIGHER LEVELS A SLIGHT
DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESS AMTS OF DUST
RETAINED IN LUNGS FOR PRLNG INTERVAL. CHRONIC: NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: WASH NOSTRILS, RINSE MOUTH. INGESTION: DILUTE
STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER. EYES: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, STARTER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN
MANUFACTURER EQUIPMENT. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Spec Gravity:3.0 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, WITH FAINT ODOR

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE, AND LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.